Nissan Juke Service and Repair Manual : Insufficient heating

Description

Symptom
• Insufficient heating
• No warm air comes out. (Air flow volume is normal.)

Diagnosis Procedure

NOTE

:
Perform self-diagnoses with CONSULT-III before performing symptom diagnosis. If any DTC is detected, perform the corresponding diagnosis.

1.CHECK COOLING SYSTEM

1. Check engine coolant level and check for leakage. Refer to the following.

- HR16DE: Refer to CO-37, "Inspection".

- MR16DDT: Refer to CO-11, "Inspection".

- K9K: Refer to CO-62, "Inspection".

2. Check radiator cap (HR16DE and MR16DDT) or reservoir tank cap (K9K). Refer to the following.

- HR16DE: Refer to CO-40, "RADIATOR CAP : Inspection".

- MR16DDT: Refer to CO-15, "RADIATOR CAP : Inspection".

- K9K: Refer to CO-65, "Inspection".

3. Check water flow sounds of the engine coolant. Refer to the following.

- HR16DE: Refer to CO-38, "Refilling".

- MR16DDT: Refer to CO-12, "Refilling".

- K9K: Refer to CO-63, "Refilling".

Is the inspection result normal? YES-1 >> HR16DE and MR16DDT: GO TO 3.

YES-2 >> K9K: GO TO 2.

NO >> Refill engine coolant and repair or replace the parts depending on the inspection results.

2.CHECK PTC HEATER OPERATION

Check PTC heater operation. Refer to HAC-294, "Component Function Check".

Is the inspection result normal? YES >> GO TO 3.

NO >> Repair or replace parts depending on the inspection results.

3.CHECK HEATER HOSE

Check installation of heater hose by visually or touching.

Is the inspection result normal? YES >> GO TO 4.

NO >> Repair or replace parts depending on the inspection results.

4.CHECK HEATER CORE

1. Check temperature of inlet hose and outlet hose of heater core.

2. Check that inlet side of heater core is hot and the outlet side is slightly lower than/almost equal to the inlet side.

CAUTION:
Always perform the temperature inspection in a short period of time because the engine coolant temperature is very hot.

Is the inspection result normal?

YES >> GO TO 5.

NO-1 >> HR16DE: Replace heater core. Refer to HA-56, "HEATER CORE : Removal and Installation".

NO-2 >> MR16DDT: Replace heater core. Refer to HA-116, "HEATER CORE : Removal and Installation".

NO-3 >> K9K: Replace heater core.

5.CHECK AIR LEAKAGE FROM EACH DUCT

Check duct and nozzle, etc. of the air conditioning system for air leakage.

Is the inspection result normal? YES >> GO TO 6.

NO >> Repair or replace parts depending on the inspection results.

6.CHECK SETTING OF TEMPERATURE SETTING TRIMMER

1. Check setting value of temperature setting trimmer. Refer to HAC-139, "Temperature Setting Trimmer".

2. Check that temperature setting trimmer is set to “− direction”.

NOTE

:
The control temperature can be set by the temperature setting trimmer.

3. Set difference between the set temperature and control temperature to “0”.

Are the symptoms solved? YES >> INSPECTION END

NO >> Replace A/C auto amp. Refer to HAC-188, "Removal and Installation".

    Insufficient cooling
    Description Symptom • Insufficient cooling • No cool air comes out. (Air flow volume is normal.) Diagnosis Procedure NOTE: Perform self-diagnoses with CONSULT-III before performing symptom diagn ...

    Compressor dose dot operate
    Description SYMPTOM Compressor dose not operate. Diagnosis Procedure NOTE: • Perform self-diagnoses with CONSULT-III before performing symptom diagnosis. If any DTC is detected, perform the co ...

    Other materials:

    CSC (concentric slave cylinder)
    Exploded View 1. Transaxle assembly 2. CSC (Concentric Slave Cylinder) : Always replace after every disassembly. : N·m (kg-m, ft-lb) Removal and Installation CAUTION: • Never reuse CSC (Concentric Slave Cylinder). Because CSC slides back to the original position every time when removi ...

    Car phone or CB radio
    When installing a car phone or a CB radio in your vehicle, be sure to observe the following precautions, otherwise the new equipment may adversely affect the electronic control modules and electronic control system harness. WARNING •  A cellular phone should not be used for any purpose wh ...

    Precautions when starting and driving
    WARNING •  Do not leave children or adults who would normally require the support of others alone in your vehicle. Pets should not be left alone either. They could accidentally injure themselves or others through inadvertent operation of the vehicle. Also, on hot, sunny days, temperature ...